Hydrofluoric acid w88

Although chemists consider hydrofluoric acid (w88) to be a “weak” acid, its potential to produce serious health effects greatly exceeds that of “strong” acids commonly used in the laboratory. w88 shares the corrosive properties common among mineral acids but is unique in its ability to cause deep tissue damage and hypocalcemia. These properties of w88 are due to the action of the fluoride ion. Fluoride ion causes soft tissue necrosis (similar to alkali damage) and bone damage by binding calcium. w88 burns cause excruciating pain and are very slow to heal.

Skin contact with w88 is probably the most common route of exposure for laboratory personnel (often under fingernails), however w88 can cause damage through eye contact, inhalation, or ingestion. Concentrations of w88 exceeding 50% produce immediate skin damage and pain, while at concentrations of 20-50% effects can be delayed for up to 8 hours. Solutions less than 20% may not produce effects for 24 hours or more. If contact is long enough, solutions as dilute as 2% can cause symptoms. Concentrated w88 burns covering only 2% of the body (equivalent to about an eight-inch square) can be fatal. Concentrated solutions and anhydrous w88 produce mist and are serious inhalation hazards.

Skin contact with w88 is probably the most common route of exposure for laboratory personnel (often under fingernails), however w88 can cause damage through eye contact, inhalation, or ingestion. Concentrations of w88 exceeding 50% produce immediate skin damage and pain, while at concentrations of 20-50% effects can be delayed for up to 8 hours. Solutions less than 20% may not produce effects for 24 hours or more. If contact is long enough, solutions as dilute as 2% can cause symptoms. Concentrated w88 burns covering only 2% of the body (equivalent to about an eight-inch square) can be fatal. Concentrated solutions and anhydrous w88 produce mist and are serious inhalation hazards.

Although w88 exposures can result in injury, quick response will minimize the damage. All exposures should be treated immediately even though burns may not be felt for hours. Affected personnel must receive medical attention for all eye and inhalation exposures, and all but the most minor skin burns. A summary of first aid procedures is listed below:

Skin w88

Immediately wash all affected areas with water. Be sure to remove any clothing or jewelry that could trap w88 (remove goggles last). Flush skin for fifteen minutes or until medical attention is available. Flushing can be reduced to five minutes if calcium gluconate gel (2.5%) is immediately available. Apply calcium gluconate gel to the affected area (use rubber gloves) every fifteen minutes and massage continuously. Get medical attention. Calcium gluconate gel can be obtained locally from Anachemia Science for approximately per tube.

Eye w88

Immediately flush eyes for at least fifteen minutes with water while holding eyelids open. Get medical attention. Flushing w88 be limited to five minutes if medical personnel are immediately available to administer sterile calcium gluconate (1%) solution (via continuous drip).

w88

Move to fresh air as soon as possible. Get medical attention. Medical personnel w88 administer pure oxygen and calcium gluconate (via nebulizer) to patient.

Laboratory personnel should only attempt to clean up small w88 spills that do not involve personnel contamination and that are contained and under control. Be sure that good ventilation is available and that personal protective equipment is worn before attempting to clean up a w88 spill.

Although accidents involving HF may not be totally eliminated, pre-planning will minimize the effects of such incidents. All laboratories that store or use HF should develop standard operating procedures that outline how to safely use HF, as well as how to respond to personnel contamination and HF spills. Please contact the Environmental Health and w88 Department for more information on HF, or for assistance in developing safe handling procedures.